Headlines > News > Europe prepares new technologies for future launchers

Europe prepares new technologies for future launchers

Published by Klaus Schmidt on Wed Nov 30, 2011 2:04 pm via: ESA
Share
More share options
Tools
Tags

ESA and the DLR German Space Center fired a Texus rocket 263 km into space on 27 November to test a new way of handling propellants on Europe’s future rockets.

Texus 48 lifted off at 10:10 GMT (11:10 CET) from the Esrange Space Centre near Kiruna in northern Sweden on its 13-minute flight.

Texus 48 launch

Texus 48 launch

During the six minutes of weightlessness – mimicking the different stages of a full spaceflight – two new devices were tested for handling super-cold liquid hydrogen and oxygen propellants and then recovered for analysis.

Building on over 30 years of Texus missions, flight 48 was the first to demonstrate a new technology for future launchers.

Texus 48 preparations

Texus 48 preparations

DLR procured the rocket for this flight, which was performed under ESA’s Cryogenic Upper Stage Technologies (CUST) project as part of the Future Launchers Preparatory Programme (FLPP).

Improved upper stage

ESA is working on a restartable cryogenic upper stage to improve Europe’s launchers.

Liquids naturally float around in weightlessness but to ensure engine ignition after a long coast in low-gravity, propellant must be held ready at the tank’s outlet using ‘capillary’ forces – the same force that helps paper towels soak up water.

Although this has already been mastered for launchers and satellites that use storable liquids, higher-performance cryogenic fluids are more difficult to handle.

Recovery of the payloads

Recovery of the payloads

On Texus 48, liquid nitrogen represented the cryogenic propellants to ease cost and safety constraints, and simplify the thermal design.

“The launch of Texus 48 demonstrating new technologies for future rockets was a success. It also shows great cooperation with DLR, where joint efforts made this flight possible on time,” said Guy Pilchen, Future Launchers Preparatory Programme Manager.

1 Comments
Start the ball rolling by posting a comment on this article!
Leave a reply
You must be logged in to post a comment.
© 2014 The International Space Fellowship, developed by Gabitasoft Interactive. All Rights Reserved.  Privacy Policy | Terms of Use